13,594
edits
Changes
update to Brett starters
Oxygen levels are an important factor to consider when deciding which of the above two methods to use for a ''Brettanomyces'' starter. ''Brettanomyces'' creates acetic acid in the presence of oxygen, potentially leading to higher levels of ethyl acetate, which is considered an off flavor in higher amounts. As the amount of oxygen increases, cell growth increases, but so does acetic acid production. The amount of acetic acid produced is species/strain dependent, so some strains may benefit from more aeration without having the negative effect of creating too much acetic acid. Other strains may need a less aerobic starter (semi-aerobic) in order to produce the highest cell count with minimal acetic acid <ref>[http://www.ncbi.nlm.nih.gov/pubmed/12655458 Brettanomyces bruxellensis: effect of oxygen on growth and acetic acid production. Aguilar Uscanga, Délia1, and Strehaiano. 2003.]</ref><ref>[http://onlinelibrary.wiley.com/doi/10.1002/(SICI)1097-0010(199712)75:4%3C489::AID-JSFA902%3E3.0.CO;2-9/abstract Role of oxygen on acetic acid production by Brettanomyces/Dekkera in winemaking. Maurizio Ciani and Luisa Ferraro. April 1999.]</ref><ref>[http://link.springer.com/article/10.1023%2FA%3A1014927129259 Acetic acid production by Dekkera/Brettanomyces yeasts. S.N. Feer. April 2002.]</ref>. In addition to acetic acid production, it has been observed that some ''Brettanomyces'' strains grown under aerobic conditions continue to produce THP when transferred to anaerobic conditions. See [[Tetrahydropyridine#Brettanomyces|THP]] for details.
This presents a sort of "catch 22" when growing ''Brettanomyces'' in a starter. The brewer must weigh the pros and cons of how much aeration to provide. If the ''Brettanomyces'' is going to be used in a [[100% Brettanomyces Fermentation]], for example, then a stir plate may be with foil covering the flask is the best choice. If the ''Brettanomyces'' is instead being pitched in secondary with the intention of long aging, then having a high cell count isn't as necessary and the risk of adding more acetic acid/ethyl acetate to an aging beer is greater. If a lot of acetic acid is produced during the starter, it is advised then they can opt to cold crash and decant the starter. ''Brettanomyces'' can have a difficult time flocculating and settling out, even when cold crashed. The brewer may need to allow a few days for the cells to fully sediment <ref>[https://www.facebook.com/groups/MilkTheFunk/permalink/1099473923414154/?comment_id=1099522943409252&offset=0&total_comments=25&comment_tracking=%7B%22tn%22%3A%22R%22%7D Conversation with Richard Preiss of Escarpment Yeast Labs on MTF. 6/26/2015.]</ref>. Additionally, ''Brettanomyces'' that is cold crashed may be slower to begin fermentation. If the brewer believes that the amount of acetic acid produced was insignificant, then cold crashing can be skipped and the entire starter can be pitched. Even if the starter has a lot of acetic acid, the amount of acetic acid in the volume of a starter is fairly insignificant once diluted into a full batch of wort or beer. If the starter is not going to be used within a month, then an aerobic starter is not the best option since the presence of a lot of acetic acid will slowly kill the ''Brettanomyces'' over time. In this case, the starter should be lightly shaken (or occasionally manually stirred), and an airlock put in place on the flask in order to keep out most of the oxygen.
Although more experiments are probably needed, agitation is believed to be an important factor for any species of microbe (yeast and bacteria). Gentle stirring on a stir plate or orbital shaker, or frequent gentle manual agitation leads to faster growth and a higher number of organisms. Agitation keeps the microbes in solution. It also maximizes the microbes' access to nutrients and disperses waste evenly. In a non-agitated starter, the microbes are limited to the diffusion rate of nutrients, leading to a slower and more stressful growth <ref>[https://www.facebook.com/groups/MilkTheFunk/permalink/1168024059892473/?comment_id=1174865305875015&reply_comment_id=1176092372418975&total_comments=1&comment_tracking=%7B%22tn%22%3A%22R9%22%7D Conversation with Bryan of Sui Generis Blog about starters and agitation. 11/09/2015.]</ref>.