13,591
edits
Changes
no edit summary
The sources of microbes that influence spontaneous fermentation are somewhat debatable, especially when referencing [[Lambic]] producers in Belgium. Although the coolship step is regarded as the main contributor to the microbial inoculation for spontaneous beers, it is often claimed that ''Brettanomyces'' living in the barrels is at least partially responsible for the secondary fermentation of spontaneous beers. Roos et al. (2018) used amplicon sequencing technology (which is better at detected so-called "[[Quality_Assurance#Viable_But_Nonculturable|viable but not culturable]]" cells) to samples the interior of barrels and foeders used in one lambic brewery that uses high-pressurized hot water and sulfur dioxide to clean them, and found surviving colonies of ''Brettanomyces anomalus'', ''B. bruxellensis'', ''B. custersianus'', ''Pediococcus'', and to a lesser extent ''Acetobacter'' and ''Lactobacillus''. The ''Acetobacter'' might be linked to older barrels that are more porous. ''Pichia'', ''Debaryomyces hansenii'' and ''Candida'' were also found in abundance in some barrels, but not others. They also found high levels of ''Cellulosimicrobium'' and ''Acinetobacter'', which have not been found to be important for lambic fermentation; the authors suspected that these were living in the wood rather than in the beer since they can metabolize cellulose. Although they are probably also not important to the fermentation of lambic, molds were found in the more porous barrels before cleaning, including ''Aspergillus'' and ''Penicillium''. No molds survived the sulfuring process and the diversity of microbes was far higher in barrels than it was for foeders, perhaps because of the higher level of oxygen exposure in barrels compared to foeders, although foeders had a much higher than expected amount of surviving ''Saccharomyces'' and ''Pichia'' <ref>[https://aem.asm.org/content/early/2018/10/15/AEM.02226-18 The interior surfaces of wooden barrels are an additional microbial inoculation source for lambic beer production. J. De Roos, D. Van der Veken, L. De Vuyst. 2018. DOI: 10.1128/AEM.02226-18.]</ref>.
James Howat of Black Project Spontaneous Ales reported conducting an experiment that showed a similar fermentation profile between a barrel fermented spontaneous beer and samples taken from the coolship and aged in glass flasks <ref>[https://www.facebook.com/groups/MilkTheFunk/permalink/1977772602250944/?comment_id=1977929225568615&reply_comment_id=1978520655509472&comment_tracking=%7B%22tn%22%3A%22R%22%7D James Howat. Milk The Funk thread on the source of ''Brettanomyces'' in lambic. 02/05/2018.]</ref>. The spontaneous beers at Black Project were produced for a few years by placing a kettle on the roof outside of the brewery to collect microbes from the air and then racked directly to barrels, so there was no influence of microbes living within the brewery (Black Project now uses a coolship inside the brewery). This led James to conduct this experiment to see how much the barrels were influencing the microbiome of the beers even after they were steamed to the [[Barrel#Sanitizing|point of possible pasteurization]]. James reported that the sensory characteristics between the barrel aged beers and the flask-aged beers were very similar, other than the obvious differences that the oak would have provided, which led him to believe that air inoculation provides a significant contribution to the microbial load of spontaneously fermented beers. Additionally, Brasserie-Brouwerij Cantillon (ref needed) and Oud Beersel <ref>[https://soundcloud.com/craftbeerbrew/podcast-episode-21-new-belgiums-wood-cellar-director-blender-lauren-limbach Lauren Limbach. Craft Beer and Brewing Magazine Podcast. Episode 21. 02/16/2018.]</ref> (~42 minutes in) are known to steam clean their barrels which might be enough to [[Barrel#Sanitizing|sanitize them]].
Other sources for the microbes include the ceilings of the breweries which are often not cleaned in Belgian lambic breweries, and the coolship itself. Some breweries have opted to craft wooden overhangs to simulate having a relatively low ceiling above the coolship (see [[Coolship#Overhangs_and_Other_Innovations|Coolship]]). As the wort cools overnight, vapor rises and condenses on the wooden ceiling or overhang above, and then drips back down into the coolship carrying any microbes that might be living on the surface of the wood. The air also carries some amount of microbes, although it is rare to find wild ''Brettanomyces'' in the air (see [[Brettanomyces#Environment_and_Survival|''Brettanomyces'' environment]]). The sources for various microbes are unknown and potentially many, and probably vary from producer to producer. Additionally, no single source is likely to be required to have a successful spontaneous fermentation.